Things to take on a long road trip
Moderators: notoptoy, S Allen, Solex68
- S Allen
- Site Admin
- Posts: 4556
- Joined: Thu Dec 05, 2002 4:57 pm
- Location: Knoxville, IA(Lake Redrock)Emory, TX
- Model: 1500/1600
- Year: Low Windshield-64-67.5
- Contact:
Things to take on a long road trip
The original list was put together by Michael "Calspeed" Carion. I have edited it and added a few items.
Items you might want to have in your car all the times:
Duct Tape
Rags & Hand Cleaner
Fire Extinguisher
Flashlight
Motor Oil
Water/Anti-freeze
Fuses or an AGC Circuit Breaker---Linda & Phil
Spare fan belt-even and old one--- DB
Nuts and bolts-various common sizes---sr311det
Toilet Paper ---Windy
Disposable Tyvec coveralls----DB
Auto Club Card "AAA" ----fairlady66
Spare key in your wallet----DB
Cash. There is no substitute. Holiday weekends can mean empty ATM's, or there just isn't one around.----DB
Bungee cords---DB
Tie wraps,(fix anything) ---DB
bailing wire, couple of feet for hot stuff ---DB
tube of 5 min epoxy ---DB
More from Dave Brsico. I don't carry a spare, usually, but have a plug kit, a fix a flat and for long trips a little 12v compressor/light. Another good thing is a 12x12 piece of 3/4 plywood to put under the jack if you're on a bad surface.
Tools:
Lug wrench
Jack, Scissor or Hydraulic
8mm to 14mm wrenches
Adjustable wrench
Standard and Phillips screwdrivers, pliers, etc.
Spark plug wrench ---DB
Hammer, you never know----DB
For a long road trip you might want to include the following items for your trip. Depending on how well you maintain your car much of the below will be over kill. I put an asterisk by the ones I would take.
Spark Plugs*
Fuel Line / 6ft. of 1/4 inch
Electric Fuel Pump
Fuel Filter*
Jumper Cables*
Fix-a-Flat
Carb floats, SU Type
Carb float gaskets
Leatherman multi-purpose tool*
Test Light, Electrical*
Wire / 14 gauge
Electrical Tape*
Brake Fluid, Dot 4 or whatever you are using
Distributor Cap*
Rotor*
Points-if you still have them
Condenser
Upper and Lower Radiator Hoses
Feeler Gauge (for valves and ignition)
Transmission Fluid (90w) w/pump
Hose Clamps, few different sizes.
Fuel Can, 2 gallons / plastic
Throttle Return Spring (*)****
Sunscreen*
Fist aid kit*
Hand Cleaner
Drinking Water
Cellular Phone*
GPS-they are cheap now*
Contact list for route*
****If one of these springs break-your throttle can hang in the "wide open" position-best to turn engine off making sure you do not lock the steering and slowly brake to a complete stop.
The tools can be placed with smaller parts in a small tool box. You can put some of the larger items in a cloth sack and tuck them into the sides of the trunk.
Another excellent idea is when traveling in a group is to spread the load across the group. That way you will still have the item you need but do not have to carry everything. --Paul
Most importantly-prepare for your trip by visually checking all fluids, belts and hoses. Ensure your tires are in good condition with the proper inflation including your spare. Have fun!!
Items you might want to have in your car all the times:
Duct Tape
Rags & Hand Cleaner
Fire Extinguisher
Flashlight
Motor Oil
Water/Anti-freeze
Fuses or an AGC Circuit Breaker---Linda & Phil
Spare fan belt-even and old one--- DB
Nuts and bolts-various common sizes---sr311det
Toilet Paper ---Windy
Disposable Tyvec coveralls----DB
Auto Club Card "AAA" ----fairlady66
Spare key in your wallet----DB
Cash. There is no substitute. Holiday weekends can mean empty ATM's, or there just isn't one around.----DB
Bungee cords---DB
Tie wraps,(fix anything) ---DB
bailing wire, couple of feet for hot stuff ---DB
tube of 5 min epoxy ---DB
More from Dave Brsico. I don't carry a spare, usually, but have a plug kit, a fix a flat and for long trips a little 12v compressor/light. Another good thing is a 12x12 piece of 3/4 plywood to put under the jack if you're on a bad surface.
Tools:
Lug wrench
Jack, Scissor or Hydraulic
8mm to 14mm wrenches
Adjustable wrench
Standard and Phillips screwdrivers, pliers, etc.
Spark plug wrench ---DB
Hammer, you never know----DB
For a long road trip you might want to include the following items for your trip. Depending on how well you maintain your car much of the below will be over kill. I put an asterisk by the ones I would take.
Spark Plugs*
Fuel Line / 6ft. of 1/4 inch
Electric Fuel Pump
Fuel Filter*
Jumper Cables*
Fix-a-Flat
Carb floats, SU Type
Carb float gaskets
Leatherman multi-purpose tool*
Test Light, Electrical*
Wire / 14 gauge
Electrical Tape*
Brake Fluid, Dot 4 or whatever you are using
Distributor Cap*
Rotor*
Points-if you still have them
Condenser
Upper and Lower Radiator Hoses
Feeler Gauge (for valves and ignition)
Transmission Fluid (90w) w/pump
Hose Clamps, few different sizes.
Fuel Can, 2 gallons / plastic
Throttle Return Spring (*)****
Sunscreen*
Fist aid kit*
Hand Cleaner
Drinking Water
Cellular Phone*
GPS-they are cheap now*
Contact list for route*
****If one of these springs break-your throttle can hang in the "wide open" position-best to turn engine off making sure you do not lock the steering and slowly brake to a complete stop.
The tools can be placed with smaller parts in a small tool box. You can put some of the larger items in a cloth sack and tuck them into the sides of the trunk.
Another excellent idea is when traveling in a group is to spread the load across the group. That way you will still have the item you need but do not have to carry everything. --Paul
Most importantly-prepare for your trip by visually checking all fluids, belts and hoses. Ensure your tires are in good condition with the proper inflation including your spare. Have fun!!
66 Stroker-Going Orange
67 SRL311-00279-resto project
Stock '72 240Z-Blue
2002 Ford F250 7.3 Diesel 2WD Hauler
2008 Toyota FJ Cruiser
2009 Smart ForTwo Passion Coupe
2013 Fiat 500 Abarth
67 SRL311-00279-resto project
Stock '72 240Z-Blue
2002 Ford F250 7.3 Diesel 2WD Hauler
2008 Toyota FJ Cruiser
2009 Smart ForTwo Passion Coupe
2013 Fiat 500 Abarth
- FairladySPL
- Roadsteraholic
- Posts: 1008
- Joined: Thu Aug 07, 2008 5:57 pm
- Location: Maryland
Re: Things to take on a long road trip
Excellent list.
The military calls it a set of "running spares" and I wish the Roadster had a bigger trunk to carry all that I would want to bring.
Of course, you could always travel in a "pack" and divide up the spare-set across multiple cars. This would work if everyone had the same issue car, but uh, how often does that happen ?
Maybe the next "list" might be the repair garages known to be friendly to the Roadster. The old-style shop in this picture has the classic belts on nails along the rafters, and a ceiling rack full of tires.
http://www.wa3vjb.com/pics/Hobb%27s%20Station.jpg" onclick="window.open(this.href);return false;
I first discovered it on some back roads during the gasoline crisis of 1973-74. Only the locals really knew the place so the lines on odd/even days were far shorter than elsewhere.
I wondered whether I could retire to running a place like this, only working on the makes and models I preferred.
The military calls it a set of "running spares" and I wish the Roadster had a bigger trunk to carry all that I would want to bring.
Of course, you could always travel in a "pack" and divide up the spare-set across multiple cars. This would work if everyone had the same issue car, but uh, how often does that happen ?
Maybe the next "list" might be the repair garages known to be friendly to the Roadster. The old-style shop in this picture has the classic belts on nails along the rafters, and a ceiling rack full of tires.
http://www.wa3vjb.com/pics/Hobb%27s%20Station.jpg" onclick="window.open(this.href);return false;
I first discovered it on some back roads during the gasoline crisis of 1973-74. Only the locals really knew the place so the lines on odd/even days were far shorter than elsewhere.
I wondered whether I could retire to running a place like this, only working on the makes and models I preferred.
You do not have the required permissions to view the files attached to this post.
--Paul / Annapolis
- Linda
- Fraternal Den Mother-RIP
- Posts: 7807
- Joined: Sat Nov 05, 2005 11:37 pm
- Location: Los Angeles
- Model: 1500/1600
- Year: High Windshield-68-70
Re: Things to take on a long road trip
Fuses!!
Linda
Linda
Sadly-Linda has passed away 2022. She was the 311's den mother and drove the first Rare-Parts ball joint project. RIP.
- fj20spl311
- Roadsteraholic
- Posts: 5025
- Joined: Mon Nov 28, 2005 3:54 pm
- Location: San Diego, Ca
Re: Things to take on a long road trip
FUSES?Linda wrote:Fuses!!
Linda
I always carry a AGC replacement Circuit Breaker.....about $5 at PEP BOYS......Its very easy to blow a hand full of fuses, trying to run down a short....
Phil
Phil
67.5 SRL311-00148 Blue (FJ cruiser VOODOO Blue)
67.5 SPL311 FJ20E teal SDS EFI
69 SRL311 SOLD
19 Raptor SCAB
67.5 SRL311-00148 Blue (FJ cruiser VOODOO Blue)
67.5 SPL311 FJ20E teal SDS EFI
69 SRL311 SOLD
19 Raptor SCAB
- sunbeam590
- Roadster Fanatic-Site Supporter
- Posts: 413
- Joined: Sat Dec 10, 2005 6:28 pm
- Location: Wingham, NSW, Australia
Re: Things to take on a long road trip
On long road trips (Nationals etc )some of the Sydney Club members carry the spare mounted on a bracket outside the boot (trunk ) and 3 or 4 members will share the one spare, freeing up exta boot space for cases etc, on the last 3 trips that I know of there has been no call for the spare.
You do not have the required permissions to view the files attached to this post.
KEVIN
69 Datsun 2000, Factory Solexes.
69 Datsun 2000, Factory Solexes.
- windy311
- Roadster Fanatic-Site Supporter
- Posts: 527
- Joined: Sun Aug 01, 2004 6:49 am
- Location: NSW Australia
- Model: 1500/1600
- Year: Low Windshield-64-67.5
-
- Roadster Nut
- Posts: 70
- Joined: Fri Oct 12, 2007 8:02 pm
Re: Things to take on a long road trip
All i have to say is what holds the car together?
Nuts and bolts.
Finding quality nuts and bolts on the road is almost impossible it seems when you need them.
Someone I know out there has a nickname after what he had to fix his roadster with.
"wing nut"
Nuts and bolts.
Finding quality nuts and bolts on the road is almost impossible it seems when you need them.
Someone I know out there has a nickname after what he had to fix his roadster with.
"wing nut"
Re: Things to take on a long road trip
Auto Club Card "AAA" Don't leave home without it.
- Linda
- Fraternal Den Mother-RIP
- Posts: 7807
- Joined: Sat Nov 05, 2005 11:37 pm
- Location: Los Angeles
- Model: 1500/1600
- Year: High Windshield-68-70
Re: Things to take on a long road trip
Ignition module
Linda
Linda
Sadly-Linda has passed away 2022. She was the 311's den mother and drove the first Rare-Parts ball joint project. RIP.
- dbrick
- Roadster Fanatic-Site Supporter
- Posts: 10084
- Joined: Thu Sep 09, 2004 11:05 pm
- Location: Kenilworth, New Jersey
Re: Things to take on a long road trip
The circuit breaker is a great idea.
My throttle spring DID break last year 150 miles from home, and I had a spare. Luckilly, I overpack
A few things not on the list that I bring..
Spark plug wrench
Spare key in your wallet
Hammer, you never know
Fan belt, (the old one you took off is fine)
Cash. There is no substitute. Holiday weekends can mean empty ATM's, or there just isn't one around.
Bungee cords
Tie wraps,(fix anything) and bailing wire, couple of feet for hot stuff
tube of 5 min epoxy
Sounds silly, but i tossed in a Tyvec coverall, like the Hazmat guys wear. It takes up no room. Occasionally I dress nice, and Murphys law being in effect..
I don't carry a spare, usually, but have a plug kit, a fix a flat and for long trips a little 12v compressor/light. Another good thing is a 12x12 piece of 3/4 plywood to put under the jack if you're on a bad surface.
Can't bring everything, but we can try.
Hagerty has roadside, and for a bit more, they will cover every regular car you own also.
I bet we will all forget to copy the phone numbers on the emergency contact list to our cell phone.
Last year we were at the Glen, in New York, on the phone to Sid in Florida trying to get part #'s from the 311's WIKI to get parts to get a car home.
My throttle spring DID break last year 150 miles from home, and I had a spare. Luckilly, I overpack
A few things not on the list that I bring..
Spark plug wrench
Spare key in your wallet
Hammer, you never know
Fan belt, (the old one you took off is fine)
Cash. There is no substitute. Holiday weekends can mean empty ATM's, or there just isn't one around.
Bungee cords
Tie wraps,(fix anything) and bailing wire, couple of feet for hot stuff
tube of 5 min epoxy
Sounds silly, but i tossed in a Tyvec coverall, like the Hazmat guys wear. It takes up no room. Occasionally I dress nice, and Murphys law being in effect..
I don't carry a spare, usually, but have a plug kit, a fix a flat and for long trips a little 12v compressor/light. Another good thing is a 12x12 piece of 3/4 plywood to put under the jack if you're on a bad surface.
Can't bring everything, but we can try.
Hagerty has roadside, and for a bit more, they will cover every regular car you own also.
I bet we will all forget to copy the phone numbers on the emergency contact list to our cell phone.
Last year we were at the Glen, in New York, on the phone to Sid in Florida trying to get part #'s from the 311's WIKI to get parts to get a car home.
Dave Brisco
Take my advice, I'm not using it"
66 2000 The Bobster
64 1500 in pieces for sale
1980 Fiat X1/9
2009 Volvo C-70
08 Expedition EL, STUPID huge but comfy
1962 Thompson Sea Lancer, possible money pit
-
- Roadster Fanatic-Site Supporter
- Posts: 145
- Joined: Sat Jan 08, 2011 9:22 pm
- Location: Sydney, Australia
- Model: 1500/1600
- Year: Low Windshield-64-67.5
Re: Things to take on a long road trip
I knew I had seen this list earlier and am glad to have found it again as I am about to head off on a 1,360 mile round trip in May and June and it will be handy to have (hope they are not needed).
My Mum turns 80 at the end of May and that will be my first destination from Sydney (Ingleburn) taking a few days of sight seeing to get there after which my lady friend is flying up to join me on the next leg to the Datsun Sports Owners Association Nationals in Bathurst. We will be taking a few days to do that leg of the trip too.
Map of the route. Not exactly but will give you an idea...
http://g.co/maps/yyjtp
I will take some pics to show once I am back.
My Mum turns 80 at the end of May and that will be my first destination from Sydney (Ingleburn) taking a few days of sight seeing to get there after which my lady friend is flying up to join me on the next leg to the Datsun Sports Owners Association Nationals in Bathurst. We will be taking a few days to do that leg of the trip too.
Map of the route. Not exactly but will give you an idea...
http://g.co/maps/yyjtp
I will take some pics to show once I am back.
Bazzman
'69 Datsun 2000 SR311-05066 Solex's (Sold March 2022)
‘67 Datsun 1600 SP311-02156 (Bought September 2022)
'05 Mazda MX5 Limited Edition #1677 of 3500
'03 Subaru Liberty Heritage
'69 Datsun 2000 SR311-05066 Solex's (Sold March 2022)
‘67 Datsun 1600 SP311-02156 (Bought September 2022)
'05 Mazda MX5 Limited Edition #1677 of 3500
'03 Subaru Liberty Heritage
- fj20spl311
- Roadsteraholic
- Posts: 5025
- Joined: Mon Nov 28, 2005 3:54 pm
- Location: San Diego, Ca
Re: Things to take on a long road trip
That's some green country......I checked out Bells Line Of Road
Phil
67.5 SRL311-00148 Blue (FJ cruiser VOODOO Blue)
67.5 SPL311 FJ20E teal SDS EFI
69 SRL311 SOLD
19 Raptor SCAB
67.5 SRL311-00148 Blue (FJ cruiser VOODOO Blue)
67.5 SPL311 FJ20E teal SDS EFI
69 SRL311 SOLD
19 Raptor SCAB
- dbrick
- Roadster Fanatic-Site Supporter
- Posts: 10084
- Joined: Thu Sep 09, 2004 11:05 pm
- Location: Kenilworth, New Jersey
Re: Things to take on a long road trip
We did 1000 miles home with the 66. Bob gave me some bare necessity spares and old tools, as we flew in. Being a well built car, the only thing needed was 5 hour energy and Tylenol.
If you're going to be in the middle of nowhere, add a few fuel filters in case you get crappy gas from a remote gas station.
If you're going to be in the middle of nowhere, add a few fuel filters in case you get crappy gas from a remote gas station.
Dave Brisco
Take my advice, I'm not using it"
66 2000 The Bobster
64 1500 in pieces for sale
1980 Fiat X1/9
2009 Volvo C-70
08 Expedition EL, STUPID huge but comfy
1962 Thompson Sea Lancer, possible money pit
- Habitat.pat
- Roadsteraholic
- Posts: 644
- Joined: Thu Jul 07, 2016 8:29 pm
- Location: Central Texas
- Model: 1500/1600
- Year: Low Windshield-64-67.5
Re: Things to take on a long road trip
I taped my spare ignition key on the back of the rear license plate in a zip lock. You can always find a screwdriver to get to it.
On my non Roadster I taped a door key. It won't start the car but it will let me in to get the ignition key I accidentally locked in.
On my non Roadster I taped a door key. It won't start the car but it will let me in to get the ignition key I accidentally locked in.
67.5 SPL311 Stroker Restomod
02 Silverado 1500 Tow vehicle
17 Camry current daily driver
Pat Horne, Near Austin, TX
We support Habitat for Humanity
A hand UP, not a hand OUT
02 Silverado 1500 Tow vehicle
17 Camry current daily driver
Pat Horne, Near Austin, TX
We support Habitat for Humanity
A hand UP, not a hand OUT
- Gregs672000
- Roadster Fanatic-Site Supporter
- Posts: 9210
- Joined: Fri Aug 07, 2009 11:47 pm
- Location: Tacoma, WA